Axis Wake Research Om 2012 Specifiche

website: www.axiswake.com • email: [email protected] On You.Tennessee PlantAxis Wake Research5075 Kimberly WayLoudon, TN 37774Phone: (865)

1-1Chapter 1BOATING SAFETYAt Axis Wake Research, safety is not an option!Safe operation of a boat is the responsibility of everyone using the boat. Bo

1-2Boating SafetySafety StatementsThroughout this manual, specific precautions and symbols identify safety relatedinformation. Follow these precaution

Boating Safety1-3DO NOT use the boarding platform for any other purpose than boarding the boat orpreparation of entering the water, and DO NOT use the

1-4Boating SafetyInsuranceThe boat owner is legally responsible for damages or injuries he or she causes. Commonsense dictates that you carry adequate

Boating Safety1-5Exhaust EmissionsIncreased exhaust (hydrocarbon) emissions pollute our water and air. Keep your enginetuned and boat hull clean for p

1-6Boating Safety2) Fire Extinguishers: A fire extinguisher is requiredif your boat has an inboard engine, or when fuel isstored in closed stowage com

Boating Safety1-7Hazardous ConditionsEvery waterway poses hazards that should be avoided. The following informationoutlines some of the hazards which

1-8Boating SafetyCarbon MonoxideCarbon Monoxide (CO) is a colorless and odorless gas produced by all engines and fuelburning appliances. Even with the

Boating Safety1-9Figure 1-5. Carbon Monoxide HazardsOperation by MinorsIf your boat will be operated by a minor, remember to have an adult present at

1-10Boating SafetyTypes of BuoysThere are several types and shapes of buoys. Buoys may be unlighted, lighted, withsound or may have both an audible an

iAll information and specifications included in this manual were in effect at the time ofapproval for printing. Axis Wake Research reserves the right,

Boating Safety1-11Right-of-WayNotice: In general, boats with less maneuverability have right-of-way overmore agile craft. You must stay clear of the v

1-12Boating SafetyOvertakingThe boat that is overtaking one ahead of it is the burdened boat and must make anyadjustments necessary to keep out of the

Chapter 2GAUGES & CONTROLSNo other ski boat manufacturer incorporates in their product as many innovative and technically advanced features as Axi

TachometerThe Axis tachometer has an alphanumeric display thatallows the user to access both boat and engineinformation. This is accomplished by using

Speedometer CruiseThe Axis speedometer has an LCD that shows the fuel level and cruise control status.The speedometer can control either the speed of

Circuit BreakersAll major boat circuits are protected from shorting and overload by resettable circuitbreakers. If a problem develops with one of the

Navigation/Anchor LightsIn the ANC (anchor) position, this switch is used to activate the all-around light on thetower. Keep the all-around light on a

Stereo PowerThe optional stereo system can be activated by either turning the ignition key on, or canbe used without the engine started by turning the

Steering SystemIt is important that you get the “feel” of your Axis boat’s steering system. Turn the wheelfrom full left to full right, and make sure

Driver’s SeatThe driver’s seat can be adjusted forward and backward bypulling the lever located on front left side of the driver’sseat. Pull lever out

iiNotes Chapter i_12_Axis_Chapter i.qxd 9/21/11 2:11 PM Page ii

SundeckMost boat models are equipped with a standard sundeckfeature designed for sunbathing comfort. The Sundeck is not to be used whilethe engine is

Swim PlatformA removable swim step is located on the stern of the boat to provide easy access into andout of the water for boat skiers and swimmers. T

Storage AreasObserver Storage AreaThe storage area behind the observer seat is accessible by opening the observer seat doorfrom left to right. Under S

Drain PlugsYour Axis is equipped with two drain plugs; one located at the transom of your boat and one T-handle located mid-ship near the driver’s sea

Tilt Steering WheelThe tilt steering wheel allows for maximum driver comfort. To adjust the height of the wheel, simply pressdown on the lever located

VentilationThe ventilation is used to remove potentially hazardous accumulation of explosive vaporsfrom the bilge areas of your boat’s hull and engine

Optional EquipmentHeaterIf your boat is equipped with a heater, you will find a HIGH/LOW accessory switch located on the dash panel.Located at the bas

Pull-Up CleatsPull-Up cleats are available for all boat models. Thesecleats will sit flush on the side of the boat deck whendepressed. To use the clea

HardwareMost of the metal hardware on your boat consists of brass, stainless steel, or aluminumand should be cleaned on a periodic basis with soap and

NotesGauges & Controls2-18 Chapter 2_12_Axis_ Chapter 2 doc.qxd 9/21/11 2:27 PM Page 18

ContentsiiiCONTENTS . . . . . . . . . . . . . . . . . . . . . iiiTABLE OF FIGURES . . . . . . . . . . . . . ivINTRODUCTION. . . . . . . . . . . . . .

3-1Chapter 3OPERATIONEveryone benefits from the safety of others.TraileringThe trailering information contained in this section describes general guid

3-2OperationSafety ChainsSafety chains on your boat trailerprovide added insurance that it will notbecome completely detached from thetowing vehicle w

Operation3-3Backing the TrailerBacking the boat trailer may sometimes be a difficult task. It is recommended that youpractice backing the trailer in a

3-4OperationWarning LabelsWarning labels are displayed at various locations throughout your new Axis to point outsafety hazards. It is important that

Operation3-5Refer to the diagram below for the location of each label.1011 Chapter 3_12_Axis_ Chapter 3 doc.qxd 9/28/11 9:14 AM Page 5

3-6OperationLoad CapacityThe U.S. Coast Guard and most maritime authorities require that boats under 20 ft have acertification or builder’s plate stat

Operation3-7Axis Wake Research reminds you that when your boat is fully loaded with the maximumnumber of persons and gear as indicated on the capacity

3-8OperationStartingFirst Start-Up of the DayOn the first start-up of the day, you may find it beneficial to “key up” once or twice toprime the fuel s

Operation3-9Starting the EngineAxis boats are equipped with sensors that constantly monitor various functions of theboat. Certain functions, if outsid

3-10OperationShifting/RunningThe throttle lever is located to the right of the driver. When the throttle is vertical, it is inthe “NEUTRAL” position.

ivTable of FiguresTABLE OF FIGURESFigure 1-1 Personal Flotation Devices . . . . . . . . . . . . . . . . . . . . . . . . 1-5Figure 1-2 Fire Extinguishe

Operation3-11SteeringIt is important that you get the “feel” of your boat’s steering system. Turn the wheel fromfull left to full right, and make sure

3-12OperationManeuvering TechniquesSteering response depends on three factors: engine position, motion and throttle.Like an automobile, high speedmane

Operation3-13DockingDocking procedures for the new boat owner usually bring surprising results. Remember,operate your boat at slow speeds to avoid acc

3-14OperationBefore tying up the boat, be sure to use enough fenders to protect the boat from damage.If possible, tie up with the bow toward the waves

Operation3-15Communication between the skier and driver is essential. Standard signals have beendeveloped by the American Waterski Association and hav

3-16OperationTowing Another BoatTowing is normally a last resort because damage can be created by stress from the towinglines or uncontrollability of

Operation3-17Propellers• A propeller can be very sharp. Be careful when you handleit. Wear a pair of protective gloves when handling anypropeller.• Re

3-18OperationRemoval1) Remove the cotter pin from the propeller shaft and discard.2) Wedge a piece of 1" x 4" wood between the propeller bla

Operation3-19Axis Exclusive Adjustable Rudder System Your Axis steering is custom calibrated at the Axis factory at the time of manufacturing. However

3-20OperationCorrosion ProtectionGalvanic corrosion (electrolysis), is the break-up of metals do to the effects of electrolyticaction. When two dissim

IntroductionvINTRODUCTIONAxis Wake Research manufactures high-performance wakeboard boats and brings newlevels of quality, performance and style to th

Chapter 4CARE ANDMAINTENANCEThe following guidelines discussed in this section will protect the investment you have made by preserving the beauty and

It is important to keep your vinyl clean at all times. Some substances can stain the vinyl ifyou leave them on for even a short period. Remove any con

ExteriorYour Axis boat is highly resistant to weathering, water pollution and minor scrapes whichoccur during normal use. However, regular care and ma

Care for Boats that are MooredDue to gelcoat discoloration, osmosis (blistering) and algae growth, it is notrecommended that you leave your boat moore

Engine Specifications Notes1) Minimum recorded compression in any one cylinder should not be less than 70% of the highest recorded cylinder.2) Measure

TransmissionCheck fluid only with engine OFF and boat floating level, or level on trailer. Thetransmission dipstick is located on the top of the trans

Rudder Stuffing BoxThe rudder stuffing box is a greaseless design and requires no regular maintenance.Dripless Shaft SealLocated in the bilge, under t

Fuel SystemFuel SystemAll Axis Boats are equipped with Pump-in-tank (PIT) fuel systems. This means the fuelpump is no longer mounted on the engine and

Care and Maintenance4-9ElectricalEngine Circuit BreakerYour engine is equipped with a 35 AMP Circuit Breaker to protect the engine electricalsystem an

4-10Care and MaintenanceBatteryA minimum of 650 cold cranking amps is the recommended battery size.Do not connectbattery cables toincorrect TerminalPo

viCertifications & StandardsHull Identification Number (HIN)Your Hull Identification Number can be found on the starboard transom of your boatbelo

Care and Maintenance4-11With this system you are required to manage the battery system, keeping both batteriescharged and never run the second battery

4-12Care and MaintenanceMiscellaneousHardwareMost of the metal hardware on your boat consists of brass, stainless steel, or aluminumand should be clea

Care and Maintenance4-13Storage and Winter Lay-upDue to the problems that can occur from improper winterization, we recommend that youtake your boat t

4-14Care and MaintenanceWinterization Re-Commission• Remove boat cover or shrink-wrap from boat.• Remove Duct tape from exhaust flaps.• Charge and ins

Care and Maintenance4-15TroubleshootingThe following charts will assist you in finding and correcting minor mechanical andelectrical problems with you

4-16Care and MaintenancePROBLEM POSSIBLE CAUSE SOLUTIONEngine will not turn • Throttle control in gear. • Shift into neutral.over • Main circuit break

Care and Maintenance4-17PROBLEM POSSIBLE CAUSE SOLUTIONThrottle/shifting • Corroded cables. • Clean and lubricate cables.problems • Defective throttle

4-18Care and MaintenanceGlossaryAFT: To the rear of the boat near the stern. Generally used to givedirections.BEAM: The widest portion of the hull.BIL

Care and Maintenance4-19IndexAAnchoring . . . . . . . . . . . . . . . . . . . . . . . . . 3-16Axis Exclusive Adjustable RudderSystem. . . . . . . . .

4-20Care and MaintenanceINSTRUCTIONSPlease complete following; check each item as completed.____ 1. Inspect prop____ 2. Check engine alignment, motor

Model Features & SpecificationsviiMODEL FEATURES &SPECIFICATIONS Chapter i_12_Axis_Chapter i.qxd 9/21/11 2:11 PM Page vii

Care and Maintenance4-21Item No. Service First 10 hours Every 50 hours Every 100 hours Annually1. Change engine oil and filter *** *** ***Pennzoil Ma

4-22Care and MaintenanceNotes Chapter 4_12_Axis_ Chapter 4 doc.qxd 9/21/11 3:24 PM Page 22

W-1AXIS WAKE RESEARCH LIMITEDWARRANTYThank you for choosing to purchase an Axis Wake Research (“Axis”)product manufactured by Malibu Boats, LLC (“Mali

W-2WarrantyLimitations and Disclaimer of Implied WarrantiesANY IMPLIED WARRANTY THAT IS FOUND TO ARISE BY STATE ORFEDERAL LAW, INCLUDING ANY IMPLIED W

WarrantyW-3What “Is” Covered by the Axis Wake Research Limited WarrantyCoverages:Base Limited Warranty For a period of twelve (12) months beginning on

W-4WarrantyGelcoat Limited Warranty For a period of twelve (12) months beginning on the date the boat is purchased by thefirst retail purchaser throu

WarrantyW-5• Damages caused by lightning, hail, rain, flooding, wind, sand, floods or otherenvironmental or natural conditions • Damages caused by at

W-6Warranty• Determination by any state or federal entity or private insurance carrier that the boat isa total loss or fit only for salvageThis Axis W

WarrantyW-7Important Additional Things to Know about the Malibu Boats Limited WarrantyIn addition to the warranty terms and exclusions noted above, be

W-8WarrantyCustomer Satisfaction ProcedureSatisfaction with your boat is very important to Axis and Malibu Boats. Ordinarily allconcerns related to yo

viii Chapter i_12_Axis_Chapter i.qxd 9/21/11 2:11 PM Page viii

website: www.axiswake.com • email: [email protected] On You.Tennessee PlantAxis Wake Research5075 Kimberly WayLoudon, TN 37774Phone: (865)